LIU Qiang,WANG Tai,SHEN Bo,et al. Operation Effect of MBBR Applied in Upgrading and Reconstruction of a Wastewater Treatment Plant in Tianjin at Low Temperature [J].China Water & Wastewater,2020,36(13):7-13.
MBBR工艺用于污水厂提标改造的低温运行效果
- Title:
-
Operation Effect of MBBR Applied in Upgrading and Reconstruction of a Wastewater Treatment Plant in Tianjin at Low Temperature
- 关键词:
- 移动床生物膜反应器; Bardenpho工艺; 低温; 高通量测序; 提标改造
- Keywords:
- MBBR; Bardenpho process; low temperature; high-throughput sequencing; upgrading and reconstruction
- 摘要:
-
天津市某污水处理厂进行提标改造，出水水质要求达到天津市《城镇污水处理厂污染物排放标准》（DB 12/599—2015）的A类标准，核心生化段采用移动床生物膜反应器(MBBR)工艺进行原位改造，将AAO工艺改为Bardenpho工艺，增设后缺氧区，增强生化系统的脱氮作用，好氧区投加悬浮载体，保障氨氮的稳定达标；深度处理工艺采用气浮、两级臭氧氧化、曝气活性炭滤池以及V型滤池，保障TP、SS、COD稳定达标。实际运行效果显示，在冬季9~11 ℃的低温条件下，污水厂出水COD、BOD5、氨氮、TN、TP、SS平均值分别为24.52、0.88、0.29、6.82、0.08、2.32 mg/L，稳定达到了提标改造目标。生化段沿程检测结果和硝化试验结果表明，悬浮载体在低温条件下优势突出，硝化速率是活性污泥的10倍，几乎承担了全部的硝化作用，Bardenpho工艺的设计破除了回流比对TN去除的限制，后置缺氧区的TN去除率为24.76%，强化了TN的去除，生化段出水氮素稳定达标。高通量测序结果显示，系统内主要的硝化菌属为Nitrospira，在MBBR区悬浮载体上的相对丰度达到13.14%，而在活性污泥中仅为0.68%。采用MBBR工艺对生化段进行原位改造，能够有效提高系统的硝化能力，是应对冬季低温、确保出水水质达标的有效措施。
- Abstract:
-
A wastewater treatment plant (WWTP) in Tianjin was upgraded, and the effluent quality was required to meet the level A criteria specified in the Discharge Standard of Pollutants for Municipal Wastewater Treatment Plant (DB 12/599-2015)in Tianjin City. The biochemical unit was reconstructed in situ by applying moving bed biofilm reactor (MBBR) technology, in which the AAO process was changed into Bardenpho process. An additional anoxic zone was added to enhance the nitrogen removal efficiency of the biochemical system, and suspended carriers were added to the aerobic zone to ensure the ammonia nitrogen always meeting the standard. Advanced treatment technologies including air flotation, twostage ozonation, aerated activated carbon filter and V-type filter were adopted to ensure the TP, SS and COD always meeting the standard. At low temperature of 9-11 ℃ in winter, COD, BOD5, NH3-N, TN, TP and SS in the effluent of the WWTP were 24.52 mg/L, 0.88 mg/L, 0.29 mg/L, 6.82 mg/L, 0.08 mg/L and 2.32 mg/L, respectively, which steadily achieved the upgrading target. The suspended carrier had a good performance at low temperature, and the nitrification rate was 10 times that of the activated sludge, indicating that almost all the nitrification was completed by the suspended carrier. The design of Bardenpho process relieved the restriction of reflux ratio to TN removal, and the TN removal efficiency in the postanaerobic zone was 24.76%, indicating that the TN removal was enhanced and nitrogen in the effluent of the biochemical section reached the standard stably. The main nitrifying bacteria in the system were Nitrospira, which had a relative abundance of 13.14% on the suspended carrier in MBBR, but only 0.68% in activated sludge. The in-situ reconstruction of the biochemical section by MBBR process could effectively improve the nitrification capacity of the system, which
was an effective measure to cope with low temperature in winter and ensure the effluent quality to meet the standard.
相似文献/References:
[1]张月,王阳,张宏伟,等.阳泉市污水处理二期工程BARDENPHO工艺设计和运行[J].中国给水排水,2020,36(16):64.
ZHANG Yue,WANG Yang,ZHANG Hong-wei,et al.Design and Operation of BARDENPHO Process in Phase Ⅱ Project of Yangquan Wastewater Treatment Plant[J].China Water & Wastewater,2020,36(13):64.
[2]杨平,周家中,管勇杰,等.基于MBBR的AAO和Bardenpho工艺改造效果对比[J].中国给水排水,2021,37(7):11.
YANG Ping,ZHOU Jia-zhong,GUAN Yong-jie,et al.Comparison of AAO and Bardenpho Processes Transformation Effect Based on MBBR[J].China Water & Wastewater,2021,37(13):11.
[3]周家中,宋平周,张爽,等.占地受限下北方某高标准新建污水厂工程设计[J].中国给水排水,2021,37(12):76.
ZHOU Jia-zhong,SONG Ping-zhou,ZHANG Shuang,et al.Engineering Design of a New High-standard Wastewater Treatment Plant with Limited Footprint Area in North China[J].China Water & Wastewater,2021,37(13):76.
[4]王秋晨,姜红,张勇,等.Bardenpho-臭氧催化氧化-双膜法用于再生水厂[J].中国给水排水,2024,40(6):103.
WANGQiu-chen,JIANG Hong,ZHANG Yong,et al.Application of Bardenpho, Ozone Catalytic Oxidation and Dual Membrane (UF & RO) Method in a Reclaimed Water Plant[J].China Water & Wastewater,2024,40(13):103.