[1]史经新,徐春艳,韩洪军.聚氨酯填料强化厌氧处理煤热解废水[J].中国给水排水,2023,39(7):102-106.
　SHIJing-xin,XUChun-yan,HANHong-jun.Anaerobic Degradation of Coal Pyrolysis Wastewater Enhanced by Polyurethane Packing Media[J].China Water & Wastewater,2023,39(7):102-106.
点击复制

聚氨酯填料强化厌氧处理煤热解废水

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期数: 2023年第7期 页码: 102-106 栏目: 出版日期: 2023-04-01
Title:
Anaerobic Degradation of Coal Pyrolysis Wastewater Enhanced by Polyurethane Packing Media
作者:
史经新1,2， 徐春艳2， 韩洪军2
（1.南京信息工程大学环境科学与工程学院 江苏省大气环境监测与污染控制高技术研究重点实验室，江苏 南京 210044；2.哈尔滨工业大学 环境学院，黑龙江 哈尔滨 150090）
Author(s):
SHI　Jing-xin1，2， XU　Chun-yan2， HAN　Hong-jun2
（1. Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control， School of Environmental Science and Engineering， Nanjing University of Information Science ＆ Technology， Nanjing 210044， China； 2. School of Environment， Harbin Institute of Technology， Harbin 150090， China）
关键词:
煤热解废水;  酚类化合物;  强化厌氧;  聚氨酯填料;  生物毒性
Keywords:
coal pyrolysis wastewater;  phenolic compounds;  enhanced anaerobic treatment;  polyurethane packing media;  biotoxicity
摘要:
针对煤热解废水内高浓度酚类化合物在厌氧工艺中降解率较低和生物毒性较强的特点，设计了以聚氨酯填料为载体的强化厌氧处理煤热解废水系统，研究了厌氧污泥反应器和聚氨酯生物膜反应器对煤热解废水中高浓度酚类化合物降解率的影响。结果表明，当进水中总酚浓度为600 mg/L时，厌氧污泥反应器和聚氨酯生物膜反应器对总酚的降解率分别为18.3%和51.89%。相比于厌氧污泥反应器，聚氨酯生物膜反应器具有较强的耐冲击负荷能力和稳定的降解率。此外，高浓度酚类化合物对大麦种子和大型溞具有较强的毒性抑制作用。相比于厌氧污泥反应器，高浓度酚类化合物经聚氨酯生物膜反应器处理后，其毒性抑制作用明显减弱。
Abstract:
The phenolic compounds with high concentration in coal pyrolysis wastewater have the characteristics of low degradation rate and high biotoxicity in anaerobic treatment process. To solve this problem, this paper designed an enhanced anaerobic sludge system packing with polyurethane for coal pyrolysis wastewater treatment, and investigated the effects of anaerobic sludge reactor and polyurethane biofilter on the degradation rate of high concentration phenolic compounds in coal pyrolysis wastewater. When the concentration of total phenol in influent was 600 mg/L, the degradation rates of total phenol in anaerobic sludge reactor and polyurethane biofilter were 18.3% and 51.89%, respectively. Compared with single anaerobic sludge reactor, the anaerobic biofilter packing with polyurethane media showed stronger impact load resistance and stable degradation rate. In addition, the high concentration phenolic compounds showed strong toxicity inhibition on barley seed and Daphnia magna. Compared with anaerobic sludge reactor, the toxicity inhibition effect of high concentration phenolic compounds was significantly reduced after the treatment of biofilter packing with polyurethane.
更新日期/Last Update: 2023-04-01