[1]王飞,陶晓瑞,庞焕岩,等.三元复合驱采出水除盐配聚中试研究[J].中国给水排水,2024,40(11):103-108.
　WANGFei,TAOXiao-rui,PANGHuan-yan,et al.Pilot Study on Desalination and Polymerization of Produced Water from Ternary Compound Flooding[J].China Water & Wastewater,2024,40(11):103-108.
点击复制

三元复合驱采出水除盐配聚中试研究

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第40卷 期数: 2024年第11期 页码: 103-108 栏目: 出版日期: 2024-06-01
Title:
Pilot Study on Desalination and Polymerization of Produced Water from Ternary Compound Flooding
作者:
王飞， 陶晓瑞， 庞焕岩， 狄茂， 吴志远， 马超， 刘文
（大庆油田水务环保公司，黑龙江 大庆 163000）
Author(s):
WANG　Fei， TAO　Xiao-rui， PANG　Huan-yan， DI　Mao， WU　Zhi-yuan， MA　Chao， LIU　Wen
（Daqing Oilfield Water and Environmental Protection Company， Daqing 163000， China）
关键词:
三元复合驱;  采出水;  电化学氧化;  超滤;  电渗析
Keywords:
ternary compound flooding;  produced water;  electrochemical oxidation;  ultrafiltration;  electrodialysis
摘要:
以砂滤出水为处理对象，采用电化学氧化-超滤-电渗析组合工艺对其进行深度处理。组合工艺的最佳条件：电化学氧化电流为40 A，pH为6.5，锌盐混凝剂投加量为800 mg/L；陶瓷膜超滤跨膜压差为0.20 MPa，膜面流速为4 m/s，浓缩倍数为5 倍，进水温度为40 ℃；电渗析运行电压为150 V，回收率为65%。在上述最佳条件下，组合工艺对悬浮物的去除率为97.1%，对含油量的去除率为83.8%，对聚合物的去除率为99.3%，对TDS的去除率为95.2%，出水水质达到《大庆油田油藏水驱注水水质指标及分析方法》（Q/SY DQ0605—2006）中“5.5.2”矿化度≤400 mg/L配聚用水要求。处理出水配聚性能试验结果表明，三元低矿化度水配聚效果更优。
Abstract:
The combined process consisting of electrochemical oxidation, ultrafiltration and electrodialysis was employed for advanced treatment of the effluent from a sand filter. The optimal conditions for the combined process were as follows: the electrochemical oxidation current was set at 40 A, with pH of 6.5 and zinc salt coagulant dosage of 800 mg/L, and the transmembrane pressure difference for ceramic membrane ultrafiltration was maintained at 0.20 MPa, with membrane surface flow rate of 4 m/s, concentration ratio of 5 times, influent temperature of 40 ℃, electrodialysis operating voltage at 150 V, and recovery rate of 65%. The removal rates of the combined process under the optimal conditions were as follows: 97.1% for suspended solids, 83.8% for oil content, 99.3% for polymer, and 95.2% for TDS. The effluent complied with the water quality for dissolving coagulant (salinity less than or equal to 400 mg/L) specified in section 5.5.2 in Indexes and Analytical Method of Injected Water Quality in Reservoir Water Flooding in Daqing Oil Field. The results of the polymerization performance test indicated that the polymerization of ternary low salinity water was superior.
更新日期/Last Update: 2024-06-01