[1]杨恬,王亮,赵斌,等.MBR中空纤维膜的臭氧微纳米气泡离线清洗方法[J].中国给水排水,2026,42(3):31-37.
　YANGTian,WANGLiang,ZHAOBin,et al.Off-line Cleaning of MBR Hollow Fiber Membranes Using Ozone Micro-Nano Bubbles[J].China Water & Wastewater,2026,42(3):31-37.
点击复制

MBR中空纤维膜的臭氧微纳米气泡离线清洗方法

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第42卷 期数: 2026年第3期 页码: 31-37 栏目: 出版日期: 2026-02-01
Title:
Off-line Cleaning of MBR Hollow Fiber Membranes Using Ozone Micro-Nano Bubbles
作者:
杨恬1， 王亮1,2， 赵斌1,2， 张朝晖1,2， 郭翔1,2， 郭志信1
（1.天津工业大学环境科学与工程学院 先进分离膜材料全国重点实验室，天津 300387；2.沧州市天津工业大学研究院，河北 沧州 061000）
Author(s):
YANG　Tian1， WANG　Liang1，2， ZHAO　Bin1，2， ZHANG　Zhaohui1，2， GUO　Xiang1，2， GUO　Zhixin1
（1. State Key Laboratory of Advanced Separation Membrane Materials， School of Environmental Science and Engineering， Tiangong University， Tianjin 300387， China； 2. Cangzhou Institute of Tiangong University， Cangzhou 061000， China）
关键词:
（1.天津工业大学环境科学与工程学院 先进分离膜材料全国重点实验室; 天津 300387; 2.沧州市天津工业大学研究院; 河北 沧州 061000）
Keywords:
membrane bioreactor (MBR);  hollow fiber membrane;  ozone micro-nano bubble;  off-line cleaning;  membrane fouling
摘要:
针对传统化学离线清洗过程中MBR中空纤维膜所产生的有害消毒副产物及酸碱废液处置等环境问题，将臭氧微纳米气泡（O3-MNBs）技术应用到MBR中空纤维膜的离线清洗，考察了其清洗效果，并对相关参数进行了优化。结果表明，在相同清洗时间下，O3-MNBs的清洗效率均高于传统酸碱清洗方法。在臭氧液相浓度为5 mg/L、清洗时间为120 min条件下，清洗效率最高，达到96.6%。此外，针对膜组件填充密度增大所导致的内部清洗不均匀问题，对O3-MNBs喷射器的布局结构进行了优化。经过优化后，对于填充密度为16.7%的膜组件，其清洗效率提升至90.5%以上；当膜丝有效长度为60 cm时，清洗效率仍能保持在88%以上。因此，O3-MNBs是一种环境友好的新型离线清洗技术，可用于MBR膜组件的离线清洗。
Abstract:
To address the environmental issues associated with harmful disinfection by?products and the disposal of acid/alkali wastewater generated during traditional off-line chemical cleaning of membrane bioreactor (MBR) hollow fiber membranes, ozone micro-nano bubbles (O3-MNBs) technology was applied to the off-line cleaning process of MBR hollow fiber membranes to investigate its cleaning effect and optimize relevant parameters. The results showed that the cleaning efficiency of O3-MNBs was consistently higher than that of traditional acid/alkali cleaning methods under the same cleaning duration. Under the conditions of ozone aqueous phase concentration of 5 mg/L and cleaning time of 120 minutes, the cleaning effect was best, reaching 96.6%. Furthermore, to address the issue of uneven internal cleaning caused by increased packing density in membrane modules, the layout structure of the O3-MNBs injectors was optimized to improve the cleaning uniformity. After optimization, for modules with a packing density of 16.7%, the cleaning efficiency increased to above 90.5%. Even when the effective fiber length was 60 cm, the cleaning efficiency remained above 88%. O3-MNBs is an environmentally friendly new cleaning technology that can be used for off?line cleaning of MBR membrane modules.
更新日期/Last Update: 2026-02-01