[1]郑浩,许丹宁,代蓓蓓,等.催化臭氧氧化联合BAC工艺深度处理石化废水[J].中国给水排水,2023,39(1):73-79.
　ZHENGHao,XUDan-ning,DAIBei-bei,et al.Catalytic Ozonation Combined with BAC Process for Advanced Treatment of Petrochemical Wastewater[J].China Water & Wastewater,2023,39(1):73-79.
点击复制

催化臭氧氧化联合BAC工艺深度处理石化废水

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期数: 2023年第1期 页码: 73-79 栏目: 出版日期: 2023-01-01
Title:
Catalytic Ozonation Combined with BAC Process for Advanced Treatment of Petrochemical Wastewater
作者:
郑浩1， 许丹宁1， 代蓓蓓2， 孙井梅1
（1.天津大学 环境科学与工程学院，天津 300350；2.中石化天津分公司 水务部，天津 300271）
Author(s):
ZHENG　Hao1， XU　Dan-ning1， DAI　Bei-bei2， SUN　Jing-mei1
（1. School of Environmental Science and Engineering， Tianjin University， Tianjin 300350， China； 2. Department of Water Affairs， Tianjin Petrochemical Company of Sinopec， Tianjin 300271， China）
关键词:
催化臭氧氧化;  生物活性炭;  石化废水;  难降解有机物;  分子质量分布;  有机物结构
Keywords:
catalytic ozonation;  biological activated carbon;  petrochemical wastewater;  refractory organic matter;  molecular weight distribution;  structure of organic matter
摘要:
针对石化废水难降解的问题，采用活性炭作为臭氧氧化单元的催化剂，并串联生物活性炭（BAC）单元，从水质变化、有机物分子质量分布和有机物结构等角度解析催化臭氧氧化对石化废水中难降解有机物的降解特性，以及对后续BAC单元出水水质的影响机理。结果表明，活性炭催化对臭氧氧化去除COD和UV254均有一定的促进作用，且对后续BAC单元去除COD和UV254的促进效果更明显，其中，对UV254的去除效果影响更大，当臭氧投加量为15和20 mg/L时，催化臭氧氧化对UV254的去除率比臭氧氧化分别提升9.4%和11.5%，后续BAC单元对UV254的去除率比无催化条件时分别提升17.0%和15.4%；催化条件对进水有机物分子质量分布的改变在O3投加量为15 mg/L时更明显，相比臭氧氧化，催化臭氧氧化对进水中不可吹扫有机碳（NPOC）的去除率提升5.4%，出水中分子质量<1 ku的NPOC比例增加6%；进水经催化臭氧氧化后，有机物结构显著改变，酚类、链烷烃类及不饱和链酯类等难生物降解有机物的种类明显减少。
Abstract:
The ozonation (activated carbon as catalyst) tandem along with biological activated carbon (BAC) was applied to degrade refractory petrochemical wastewater. From the perspectives of water quality change, molecular weight distribution and structure of organic matter, the degradation of refractory organic matter in petrochemical wastewater by catalytic ozonation was investigated and its influence on the effluent quality of subsequent BAC unit was analyzed. The catalytic ozonation had a certain enhancement effect on the removal of COD and UV254, and the enhancement effect on the subsequent BAC unit was more obvious, espesdcially for UV254. When the ozone dosage was 15 mg/L and 20 mg/L, compared with the ozonation without catalyst, the removal rate of UV254 by catalytic ozonation was increased by 9.4% and 11.5%, and the removal rate of UV254 by subsequent BAC unit was increased by 17.0% and 15.4%, respectively. The change of catalytic condition on molecular weight distribution of organic matter in influent was more obvious when the dosage of ozone was 15 mg/L. Compared with ozonation, the catalytic ozonation increased the removal rate of NPOC by 5.4%, and the proportion of NPOC with molecular weight less than 1 ku increased by 6%. After the influent was catalyzed by ozonation, the structure of organic matters was significantly changed, and the types of refractory organics such as phenolic, alkanes and unsaturated chain esters were significantly reduced.

相似文献/References:

[1]陶辉,厉彦辉,周伟青,等.针对低温期有机物去除率低的生物活性炭更换探究[J].中国给水排水,2022,38(9):33.
　TAOHui,LIYan-hui,ZHOUWei-qing,et al.Research on the Replacement of Biological Activated Carbon for Low Organic Matter Removal Rate during Low Temperature Period[J].China Water & Wastewater,2022,38(1):33.
[2]刘嘉琪,胡侃,庄星宇,等.自来水厂失效生物活性炭再生技术研究及应用分析[J].中国给水排水,2022,38(10):25.
　LIUJia-qi,HU Kan,ZHUANG Xing-yu,et al.Research and Application Analysis of Regeneration Technology for Ineffective Biological Activated Carbon in Waterworks[J].China Water & Wastewater,2022,38(1):25.

更新日期/Last Update: 2023-01-01