[1]区雪连,郭艳平,黄冠英,等.基于双风道大风量成型的污泥低温干化中试研究[J].中国给水排水,2023,39(11):115-121.
　OUXue-lian,GUOYan-ping,HUANGGuan-ying,et al.A Pilot Study on Low-temperature Sludge Drying Process Based on Double Air Duct and Large Air Volume[J].China Water & Wastewater,2023,39(11):115-121.
点击复制

基于双风道大风量成型的污泥低温干化中试研究

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期数: 2023年第11期 页码: 115-121 栏目: 出版日期: 2023-06-01
Title:
A Pilot Study on Low-temperature Sludge Drying Process Based on Double Air Duct and Large Air Volume
作者:
区雪连1,2， 郭艳平1,3， 黄冠英3， 黄擎英3， 朱刚利1， 张豪3， 潘霆峰1， 马凯1， 胡珈睿1
（1.广东环境保护工程职业学院 广东省固体废弃物资源化与重金属污染控制工程技术研究中心，广东 佛山 528216；2.广东环院环境工程有限公司，广东 广州 510665；3.广东吉康环境系统科技有限公司，广东 佛山 528200）
Author(s):
OU　Xue-lian1，2， GUO　Yan-ping1，3， HUANG　Guan-ying3， HUANG　Qing-ying3， ZHU　Gang-li1， ZHANG　Hao3， PAN　Ting-feng1， MA　Kai1， HU　Jia-rui1
（1. Guangdong Engineering and Technology Research Center of Solid Waste Resource Recovery and Heavy Metal Pollution Control， Guangdong Polytechnic of Environmental Protection Engineering， Foshan 528216， China； 2. Guangdong Huanyuan Environmental Engineering Co. Ltd.， Guangzhou 510665， China； 3. Guangdong Jikang Environmental System Technology Co. Ltd.， Foshan 528200， China）
关键词:
低温干化;  双风道;  市政污泥;  能效比
Keywords:
low-temperature drying;  double air duct;  municipal sludge;  energy efficiency ratio
摘要:
针对含水率高或黏性大污泥干化效率低等问题，开展了市政污泥低温干化工艺中试研究，利用双风道大风量成型技术，验证低温干化设备运行的可靠性与适应性，探讨不同运行参数条件下对机组能效的影响。结果表明，该中试机组能够连续稳定运行，当干化温度为55~70 ℃时，污泥含水率从80%降低至30%以下，机组平均单位能耗除水量可达3.72 kg/（kW·h），处理湿污泥的能耗为192 kW·h/t。
Abstract:
Aiming at the low drying efficiency of sludge with high moisture content or high viscosity, a pilot study on municipal sludge low-temperature drying process was carried out. The reliability and adaptability of the low-temperature drying equipment was verified by using double air duct and large air volume technology, and the influence of different operating parameters on the energy efficiency of the unit was discussed. The pilot unit ran continuously and stably. When the drying temperature was between 55 ℃ and 70 ℃, the moisture content of the sludge was reduced from 80% to less than 30%. The average unit energy consumption of water removal reached 3.72 kg/(kW·h), and the energy consumption of wet sludge treatment was 192 kW·h/t.

相似文献/References:

[1]颜莹莹,孟春霖,梁远,等.连续深度脱水耦合低温干化工艺用于鹰潭污泥处理厂[J].中国给水排水,2020,36(16):105.
　YAN Ying-ying,MENG Chun-lin,LIANG Yuan,et al.Continuous Deep Dewatering Coupled with Low Temperature Drying Process in Yingtan Sludge Treatment Plant[J].China Water & Wastewater,2020,36(11):105.
[2]吕开雷,杨淘,陈紫君,等.电解铝烟气余热低温干化处理市政污泥工程应用[J].中国给水排水,2021,37(12):120.
　Lü Kai-lei,YANG Tao,CHEN Zi-jun,et al.Application of Low Temperature Drying in Municipal Sludge Treatment with Waste Heat of Electrolytic Aluminum Flue Gas[J].China Water & Wastewater,2021,37(11):120.

更新日期/Last Update: 2023-06-01