[1]金润,李祥,谈新伟,等.高铁酸钾氧化剩余污泥效能及破解液性质[J].中国给水排水,2023,39(17):118-123.
　JINRun,LIXiang,TANXin-wei,et al.Performance of Potassium Ferrate for Excess Sludge Oxidation and Property of Cracking Solution[J].China Water & Wastewater,2023,39(17):118-123.
点击复制

高铁酸钾氧化剩余污泥效能及破解液性质

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第39卷 期数: 2023年第17期 页码: 118-123 栏目: 出版日期: 2023-09-01
Title:
Performance of Potassium Ferrate for Excess Sludge Oxidation and Property of Cracking Solution
作者:
金润1,2， 李祥1,2,3， 谈新伟1,2， 夏子翔1,2， 黄勇1,2， 马军3， 倪敏1,2
（1.苏州科技大学 环境科学与工程学院，江苏 苏州 215002；2.苏州科技大学 环境生物技术研究所，江苏 苏州 215002；3.哈尔滨工业大学环境学院 城市水资源与水环境国家重点实验室，黑龙江 哈尔滨 150090）
Author(s):
JIN　Run1，2， LI　Xiang1，2，3， TAN　Xin-wei1，2， XIA　Zi-xiang1，2， HUANG　Yong1，2， MA　Jun3， NI　Min1，2
（1. School of Environmental Science and Engineering， Suzhou University of Science and Technology， Suzhou 215002， China； 2. Institute of Environmental Biotechnology， Suzhou University of Science and Technology， Suzhou 215002， China； 3. State Key Laboratory of Urban Water Resource and Environment， School of Environment， Harbin Institute of Technology， Harbin 150090， China）
关键词:
高铁酸钾;  污泥破解;  剩余污泥;  氧化;  胞外聚合物
Keywords:
potassium ferrate;  sludge cracking;  excess sludge;  oxidation;  extracellular polymeric substances
摘要:
从污泥固体氧化程度（可挥发性悬浮固体VSS、污泥沉降比SV、污泥体积指数SVI、中值粒径）、污泥脱水性能（污泥比阻）和破解后液相中各类物质的浓度水平（TOC、溶解性有机物SCOD、NH4+-N、TN、PO43--P、TP、多糖、蛋白质）方面，考察了高铁酸钾投加量对剩余污泥固体的氧化性能和氧化后破解液的水质特性。结果表明，随着高铁酸钾投加量的增加，污泥VSS逐渐下降，中值粒径先略微下降后上升，污泥比阻急剧上升后下降，沉降性能变化不显著。TOC、SCOD、TN、PO43--P、TP、多糖和蛋白质浓度均呈现先快速后缓慢的上升趋势，当投加量为30 mg/gSS（以Fe计）时，上述指标氧化破解后的浓度分别为838、2 153、134、22、29、156和514 mg/L，污泥破解度（DDCOD）为16%，溶胞比（ξ）为0.16，在该投加量下，可以较为经济地氧化破解剩余污泥。
Abstract:
This paper investigated the effect of potassium ferrate dosage on the oxidation performance of excess sludge solids and the water quality characteristics of the cracked solution after oxidation from the aspects of sludge solid oxidation degree (VSS, SV, SVI and median particle size), sludge dewatering performance (sludge specific resistance) and concentration of various substances in the liquid phase after cracking (TOC, SCOD, NH4+-N, TN, PO43--P, TP, polysaccharide and protein). With the increase of potassium ferrate dosage, the volatile suspended solids decreased gradually, the median particle size decreased slightly at first and then increased, the specific resistance of sludge increased sharply and then decreased, and the settling velocity of sludge did not change significantly. The TOC, SCOD, TN, PO43--P, TP and concentrations of polysaccharide and protein all showed a trend of rapid rise followed by slow rise. When the dosage was 30 mg/gSS (calculated as Fe), the concentrations of the above indexes after oxidation were 838 mg/L, 2 153 mg/L, 134 mg/L, 22 mg/L, 29 mg/L, 156 mg/L and 514 mg/L, respectively, the degree of sludge disintegration was 16%, and the cell lysis ratio was 0.16. At this dosage, the excess sludge could be oxidized and cracked more economically.

相似文献/References:

[1]关鹤达,杨博暄,温沁雪,等.高铁酸钾强化磁絮凝去除污水厂二级出水有机物[J].中国给水排水,2023,39(21):73.
　GUANHe-da,YANGBo-xuan,WENQin-xue,et al.Potassium Ferrate Enhanced Magnetic Flocculation for the Removal of Organic Matters in Effluent from Secondary Treatment Process[J].China Water & Wastewater,2023,39(17):73.

更新日期/Last Update: 2023-09-01