[1]周明飞,连坤宙,王璟,等.电渗析技术处理脱硫废水的效果分析[J].中国给水排水,2020,36(21):80-86.
　ZHOU Ming-fei,LIAN Kun-zhou,WANG Jing,et al.Efficiency Analysis of Desulfurization Wastewater Treated by Electrodialysis Technology[J].China Water & Wastewater,2020,36(21):80-86.
点击复制

电渗析技术处理脱硫废水的效果分析

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第36卷 期数: 2020年第21期 页码: 80-86 栏目: 出版日期: 2020-11-01
Title:
Efficiency Analysis of Desulfurization Wastewater Treated by Electrodialysis Technology
作者:
周明飞1，连坤宙1，王璟1，刘亚鹏1，毛进1，颜秉诚2，李尊峰2，王永前2
(1.西安热工研究院有限公司，陕西西安710054；2.华能济宁运河发电有限公司，山东济宁272000)
Author(s):
ZHOU Ming-fei1，LIAN Kun-zhou1，WANG Jing1，LIU Ya-peng1，MAO Jin1，YAN Bing-cheng2，LI Zun-feng2，WANG Yong-qian2
(1. Xi’an Thermal Power Research Institute Co. Ltd.， Xi’an 710054， China; 2. Huaneng Jining Canal Power Generation Co.Ltd.， Jining 272000， China)
关键词:
脱硫废水; 电渗析; 反渗透; 浓缩
Keywords:
desulfurization wastewater; electrodialysis; reverse osmosis; concentration
摘要:
脱硫废水水质复杂、含盐量高，是目前火电企业节水减排工作的难点。针对脱硫废水的特点，研究电渗析（ED）工艺处理脱硫废水的效果。结果表明，当循环流量为10 m3/h、电流密度为160 A/m2时，电渗析工艺可将溶解固形物（TDS）浓度约为50 g/L的脱硫废水浓缩至200 g/L左右，脱盐能耗最低为8.78 kW·h/m3；倒极可有效去除膜表面的沉积垢层，降低ED脱盐能耗；通过联合RO工艺可实现脱硫废水的两步脱盐，RO系统在50%回收率下脱盐率高于98%，产水中TDS为0.4 g/L，可用作循环水补充水、脱硫工艺用水等电厂其他系统的补水。
Abstract:
Desulfurization wastewater has the characteristics of complex water quality and high salinity, which is the difficulty of water saving and emission reduction in thermal power enterprises. According to the characteristics of desulfurization wastewater, the treatment effect of electrodialysis (ED) process on desulfurization wastewater was explored. When circulating flow and current density were 10 m3/h and 160 A/m2, ED could concentrate desulfurization wastewater with total dissolved solids (TDS) content of about 50 g/L to about 200 g/L, and the minimum desalting energy consumption was 8.78 kW·h/m3. The inverted pole could effectively remove the deposited scale layer on the membrane surface and reduce ED desalting energy consumption. Its combination with RO could achieve two-step desalting of desulfurization wastewater. The desalting rate of RO system was higher than 98% and TDS in effluent was 0.4 g/L under the condition of 50% recovery rate, which could be used as supplement water of the circulating water, desulfurization process water and other supplement water of the power plant.

相似文献/References:

[1]倪亭亭,王云钟,吴永明,等.湿法烟气脱硫废水处理工程实例[J].中国给水排水,2022,38(4):109.
　NITing-ting,WANGYun-zhong,WUYong-ming,et al.Case of Wet Flue Gas Desulfurization Wastewater Treatment Project[J].China Water & Wastewater,2022,38(21):109.
[2]陈丽娜,尤良洲,韩倩倩,等.燃煤电厂全厂废水零排放改造工程设计及运行效果[J].中国给水排水,2023,39(20):132.
　CHEN Li-na,YOULiang-zhou,HANQian-qian,et al.Design and Operation Effect of a Wastewater Zero Discharge Reconstruction Project in Coal-fired Power Plant[J].China Water & Wastewater,2023,39(21):132.

更新日期/Last Update: 2020-11-01