XIA Yi-fan,WANG Bing-jie,TU Ling-bo,et al.Treatment of Food Waste Digestate by DMBR with Partial Nitrification and Denitrification[J].China Water & Wastewater,2021,37(7):27-33.
DMBR短程硝化反硝化处理餐厨垃圾厌氧沼液
- Title:
- Treatment of Food Waste Digestate by DMBR with Partial Nitrification and Denitrification
- Keywords:
- dynamic membrane bioreactor; food waste; digestate; partial nitrification and denitrification
- 摘要:
- 以中空玻璃纤维编织管作为膜组件材料，自行设计制作了一套动态膜生物反应器(DMBR)，研究了该装置在短程硝化反硝化条件下对餐厨垃圾厌氧沼液的处理效果。结果表明，通过逐渐提高沼液比例并控制DO浓度为0.8~1.2 mg/L、温度为35 ℃，可在16 d左右基本实现DMBR短程硝化反应的启动。系统稳定运行阶段，当进水COD和NH+4-N浓度均值分别为6 944和650 mg/L、水力停留时间（HRT）为30 h时，COD、NH4+-N和TN去除率分别可达92%、92%和68%，COD和NH4+-N容积负荷分别达到5.13 kg/(m3·d)和0.48 kg/(m3·d)，NO2--N积累率稳定在84%以上、最高值达到90.38%。经处理后，餐厨垃圾厌氧沼液可稳定达到纳管标准，其溶解性微生物代谢产物荧光峰几乎完全被去除，说明该工艺可显著降解甚至完全去除类蛋白物质。
- Abstract:
- A set of dynamic membrane bioreactor (DMBR) was designed and manufactured with hollow glass fiber braided tube as membrane module, and the treatment effect of the device on food waste digestate under the condition of partial nitrification and denitrification was investigated. Start-up of the partial nitrification of the DMBR could be achieved within about 16 days by gradually increasing the proportion of digestate and controlling the DO concentration between 0.8-1.2 mg/L and the temperature at 35 ℃. When the average COD and NH4+-N were 6 944 mg/L and 650 mg/L, and HRT was 30 h, the removal rates of COD, NH4+-N and TN were 92%, 92% and 68%, respectively, and the volumetric loads of COD and NH4+-N were 5.13 kg/(m3·d) and 0.48 kg/(m3·d), respectively. The accumulation rate of NO2--N was more than 84%, and the highest value was 90.38%. The concentration of the pollutants in the treated food waste digestate could meet the discharge standard for sewage entering into sewer network, and the fluorescence peak of the dissolved microbial metabolites was almost removed completely, which showed that the process could significantly degrade or even completely remove the protein-like substances.
相似文献/References:
[1]刘常青,陈琬,曾艺芳,等.SARD与CSTR反应器半连续发酵产氢能力对比[J].中国给水排水,2018,34(21):7.
LIU Chang qing,CHEN Wan,ZENG Yi fang,et al.Hydrogen Production Capacity of Semi continuous Fermentation of SARD and CSTR Bio hydrogen Production Reactor[J].China Water & Wastewater,2018,34(7):7.
[2]王华金.餐厨垃圾全物料湿式厌氧消化产沼技术的工程应用[J].中国给水排水,2021,37(8):95.
WANG Hua-jin.Engineering Application of Wet Anaerobic Digestion and Biogas Production Technology for Full-scale Food Waste[J].China Water & Wastewater,2021,37(7):95.
[3]李义烁,梁远,颜莹莹,等.餐厨垃圾/市政污泥/城市粪便联合厌氧消化沼液处理设计[J].中国给水排水,2021,37(14):56.
LI Yi-shuo,LIANG Yuan,YAN Ying-ying,et al.Design of Treatment Process of Biogas Slurry from Anaerobic Co-digestion of Kitchen Waste/Municipal Sludge/Urban Excrement[J].China Water & Wastewater,2021,37(7):56.
[4]李月中,谭婧,宫亚斌,等.中高温过渡区餐厨垃圾厌氧工程案例分析[J].中国给水排水,2021,37(20):106.
LI Yue-zhong,TAN Jing,GONG Ya-bin,et al.Case Study of a Food Waste Anaerobic Digestion Biogas Project at Mesophilic and Thermophilic Temperature[J].China Water & Wastewater,2021,37(7):106.
[5]梁玉帅,王侃宏,徐宇峰,等.餐厨垃圾湿法厌氧处理的污泥流变性特征及其成因[J].中国给水排水,2023,39(13):117.
LIANGYu-shuai,WANGKan-hong,XUYu-feng,et al.Rheological Characteristics of Sludge from Wet Anaerobic Digestion of Kitchen Waste and Its Causes[J].China Water & Wastewater,2023,39(7):117.
[6]程晓格,王琬,邓冠勇,等.CaO2预处理耦合ZVI强化含油餐厨垃圾厌氧消化[J].中国给水排水,2024,40(1):90.
CHENGXiao-ge,WANGWan,DENGGuan-yong,et al.Enhanced Anaerobic Digestion of Greasy Food Waste with Calcium Peroxide Pretreatment Coupled with Zero-valent Iron[J].China Water & Wastewater,2024,40(7):90.