LIXuan,LIUWu-ping,ZHOUQiong,et al.Comparison of Treatment Efficiency of Composite Magnetic Seed Coagulation and Magnetic Coagulation on Black and Odorous Water[J].China Water & Wastewater,2024,40(7):13-18.
复合磁种混凝与磁混凝处理黑臭水体效能比较
- Title:
- Comparison of Treatment Efficiency of Composite Magnetic Seed Coagulation and Magnetic Coagulation on Black and Odorous Water
- Keywords:
- magnetic coagulation; composite magnetic seed; zeolite; nano-Fe3O4; black and odorous water
- 摘要:
- 在制备和表征纳米Fe3O4-沸石复合磁种的基础上，系统比较了混凝、磁混凝和复合磁种混凝三种工艺对黑臭水体的处理效能。结果表明，复合磁种中铁元素含量约为20.0%，沸石的骨架结构和成分未被改变。聚合氯化铝（PAC）和磁种投加量分别为60 mg/L和1～2 g/L时，磁混凝和复合磁种混凝可获得较优的黑臭水体处理效果。磁混凝可强化混凝效果，提高对浊度、TP和COD的去除率，但无法有效去除氨氮；复合磁种混凝可有效去除水中氨氮，全面提升出水水质。黑臭水体中的污染物主要以溶解态形式存在，混凝和磁混凝不能有效去除溶解性污染物，因此对氨氮和COD的去除效果较差；但可通过化学除磷获得较高的TP去除率。复合磁种混凝可利用沸石的离子交换和吸附作用强化对溶解性污染物的去除，获得较好的氨氮和COD去除效果；同时，还可利用负载的纳米Fe3O4实现极限除磷。
- Abstract:
- Based on preparation and characterization of nano-Fe3O4 and zeolite composite magnetic seed, the treatment efficiency of coagulation, magnetic coagulation and composite magnetic seed coagulation on black and odorous water was compared. The results showed that the content of iron in the composite magnetic seed was about 20.0%, and the skeleton structure and composition of zeolite were not changed. When PAC dosage was 60 mg/L and magnetic seed dosage was 1-2 g/L, magnetic coagulation and composite magnetic seed coagulation could obtain optimal removal effects on black and odorous water. Magnetic coagulation enhanced the coagulation effect and increased the removal rate of turbidity, TP and COD, but could not effectively remove ammonia nitrogen. The composite magnetic seed coagulation effectively removed ammonia nitrogen in water and comprehensively improved effluent quality. The pollutants in black and odorous water mainly existed in the form of dissolved state, and coagulation and magnetic coagulation could not effectively remove dissolved pollutants, so the removal effects of ammonia nitrogen and COD were poor. However, higher TP removal rate was obtained through chemical phosphorus removal. Composite magnetic seed coagulation could strengthen the removal of dissolved pollutants by ion exchange and adsorption of zeolite, and obtained better ammonia nitrogen and COD removal. Moreover, composite magnetic seed coagulation achieved complete phosphorus removal by loaded nano-Fe3O4.
相似文献/References:
[1]熊建英.MBBR+磁混凝工艺用于污水处理厂提标改造[J].中国给水排水,2018,34(20):50.
XIONG Jian ying.Application of MBBR + Magnetic Coagulation Process for Upgrading of Wastewater Treatment Plant[J].China Water & Wastewater,2018,34(7):50.
[2]周家中,宋平周,张爽,等.占地受限下北方某高标准新建污水厂工程设计[J].中国给水排水,2021,37(12):76.
ZHOU Jia-zhong,SONG Ping-zhou,ZHANG Shuang,et al.Engineering Design of a New High-standard Wastewater Treatment Plant with Limited Footprint Area in North China[J].China Water & Wastewater,2021,37(7):76.
[3]丁静,张建良,任烨,等.混凝+A/O+气浮+臭氧+磁混凝工艺处理印染废水[J].中国给水排水,2021,37(20):112.
DING Jing,ZHANG Jian-liang,REN Ye,et al.Treatment of Dyeing Wastewater by a Combined Process of Coagulation, A/O, Flotation, Ozone, and Magnetic Coagulation[J].China Water & Wastewater,2021,37(7):112.
[4]方华,杨顺,赵金宇,等.磁混凝对黑臭水体中污染物的去除特性[J].中国给水排水,2023,39(15):70.
FANGHua,YANGShun,ZHAOJin-yu,et al.Characteristics of Magnetic Coagulation for Pollutants Removal from Black and Odorous Water[J].China Water & Wastewater,2023,39(7):70.