WEIXiang,LIHuai-bo,ZHENGKai-kai,et al.Operation Evaluation of Xibei Wastewater Treatment Plant in Wuxi and Its Optimization[J].China Water & Wastewater,2024,40(3):95-100.
无锡锡北污水处理厂运行评估及优化改造方案
- Title:
- Operation Evaluation of Xibei Wastewater Treatment Plant in Wuxi and Its Optimization
- Keywords:
- upgrading and reconstruction; wastewater treatment plant; full process test analysis; characteristics of activated sludge
- 摘要:
- 以无锡锡北污水处理厂为例,通过全流程测试和活性污泥特性研究,分析存在的问题,并提出改造方案。结果表明,该污水厂的硝化速率(以NH3-N计)为1.2 mg/(gVSS·h),处于较低水平,且曝气生物滤池无实际硝化效果,导致冬季氨氮存在超标风险。此外,由于同步化学除磷的抑制作用,活性污泥的最大厌氧释磷速率(以PO43--P计)为0.66 mg/(gVSS·h),处于偏低水平,生物除磷效果较差。为了解决该污水厂存在的问题,同时遵循尽量依托已有构筑物、减少工程投资及运行费用的原则,通过在好氧池设计悬浮填料系统来弥补硝化速率低及水力停留时间较短的不足;将现有曝气生物滤池改造为反硝化滤池,强化系统脱氮效果;此外,新建高效沉淀池,消除同步化学除磷对生物除磷的不利影响。
- Abstract:
- This paper analyzed the existing problems and proposed the improvement scheme of Xibei Wastewater Treatment Plant in Wuxi according to the whole process test and activated sludge characteristics. The nitrification rate (measured by NH3-N) of the plant was at a low level of 1.2 mg/(gVSS-h), and the existing biological aerated filter had no actual nitrification ability, resulting in the risk of exceeding the ammonia nitrogen limit specified in the discharge standard in winter. In addition, due to the inhibition of simultaneous chemical phosphorus removal, poor biological phosphorus removal performance was obtained, and the maximum specific anaerobic phosphorus release rate (measured by PO43--P) of activated sludge was at a low level of 0.66 mg/(gVSS-h). The low nitrification rate and short hydraulic retention time were compensated by constructing suspension filler system in the aerobic tank, so as to solve the problems existing in the plant, follow the principle of relying on the existing structures as much as possible, and reduce the project investment and operating costs. The existing biological aerated filter was transformed into a denitrification filter to enhance the nitrogen removal performance of the system, and a new high-efficiency sedimentation tank was built to eliminate the adverse effects of simultaneous chemical phosphorus removal on biological phosphorus removal.
相似文献/References:
[1]熊建英.MBBR+磁混凝工艺用于污水处理厂提标改造[J].中国给水排水,2018,34(20):50.
XIONG Jian ying.Application of MBBR + Magnetic Coagulation Process for Upgrading of Wastewater Treatment Plant[J].China Water & Wastewater,2018,34(3):50.
[2]卢如,巨志剑,杜琼.采用A/O工艺的污水处理厂提标改造工程设计[J].中国给水排水,2018,34(20):56.
LU Ru,JU Zhi jian,DU Qiong.Upgrading and Reconstruction Project Design of Wastewater Treatment Plant with A/O Process[J].China Water & Wastewater,2018,34(3):56.
[3]周亚梁,黄东月.南方某污水处理厂提标改造工艺运行优化[J].中国给水排水,2020,36(8):113.
[4]许晓明,刘宇心,闫萍,等.以工业废水为主的污水厂准Ⅳ类水质提标扩建工程设计[J].中国给水排水,2020,36(18):60.
XU Xiao-ming,LIU Yu xin,YAN Ping,et al.A Design Case of Upgrading and Expansion Project to Meet the Quasi-Ⅳ Class Standard in a WWTP with Industrial Wastewater as Its Major Influent[J].China Water & Wastewater,2020,36(3):60.
[5]聂健锋,曾超.三峡库区Carrousel氧化沟工艺提标升级改造设计[J].中国给水排水,2020,36(18):66.
NIE Jian-feng,ZENG Chao.Design of Upgrading and Reconstruction of Carrousel Oxidation Ditch Process in Three Gorges Reservoir Area[J].China Water & Wastewater,2020,36(3):66.
[6]张莉,余国富,瞿露,等.重庆市某污水处理厂一级A提标改造运行效果分析[J].中国给水排水,2020,36(18):95.
ZHANG Li,YU Guo-fu,QU Lu,et al.Analysis on the Operation Effect of a WWTP Upgrading Project for the Firstlevel A Standard in Chongqing[J].China Water & Wastewater,2020,36(3):95.
[7]马丽芳,陈菊香,孙锐.克拉玛依市某污水处理厂一级A提标改造工程实例[J].中国给水排水,2020,36(18):122.
MA Li-fang,CHEN Ju-xiang,SUN Rui.A WWTP Upgrading Reconstruction Project to Meet the First Level A Discharge Standard in Karamay[J].China Water & Wastewater,2020,36(3):122.
[8]孙高升,王东东,弋凡,等.淮河流域地表水类Ⅳ类标准污水深度处理工艺研究[J].中国给水排水,2020,36(19):16.
SUN Gao-sheng,WANG Dong-dong,YI Fan,et al.Advanced Wastewater Treatment Process with Effluent Quality Meeting Level Quasi Ⅳ Criteria of Surface Water in Huai River Basin[J].China Water & Wastewater,2020,36(3):16.
[9]李亮,邱宏俊.改良A2/O氧化沟强化生化处理技术用于污水厂提标改造[J].中国给水排水,2020,36(20):124.
LI Liang,QIU Hong-jun.Application of Improved A2/O Oxidation Ditch Enhanced Biochemical Treatment Process for Upgrading the Wastewater Treatment Plant[J].China Water & Wastewater,2020,36(3):124.
[10]黄志心.城镇污水处理厂提标改造实践与思考[J].中国给水排水,2020,36(22):48.
HUANG Zhi-xin.Practice and Thinking of Upgrading and Reconstruction of Municipal Wastewater Treatment Plant[J].China Water & Wastewater,2020,36(3):48.