LIULiang,LIUWei-hua,LIUZhi-xiao.Characteristics of Grit Distribution in Municipal Wastewater and Grit Removal Efficiency of Different Grit Chambers[J].China Water & Wastewater,2023,39(21):61-66.
城市污水含砂特征及不同沉砂池除砂效率研究
- Title:
- Characteristics of Grit Distribution in Municipal Wastewater and Grit Removal Efficiency of Different Grit Chambers
- Keywords:
- municipal wastewater; grit chamber; grit particle distribution; grit removal rate; multilayer vortex process
- 摘要:
- 为明确我国城市污水含砂特征，向除砂工艺优化设计提供参考，采集了6 座不同城市污水处理厂的沉砂池进出水，分析了砂粒分布特征，并计算了沉砂池的除砂率。结果表明，城市污水含砂量介于1.28~80.96 mg/L之间，粒径>212 μm的砂粒（粗砂）占22.25%~74.14%；各污水厂进水含砂量及粒径分布特征均存在明显差异。各污水厂使用中的曝气沉砂池或旋流沉砂池实测除砂目标粒径介于150~212 μm之间，加权平均除砂率介于9.16%~52.02%之间。降低旋流沉砂池表面负荷至60 m/h以下，或者延长曝气沉砂池停留时间至10 min以上，可以将沉砂池除砂精度提升至150 μm以下，并可有效提升沉砂池加权平均除砂率。
- Abstract:
- This paper collected the wastewater samples from the inlet and outlet of grit chambers in six different municipal wastewater treatment plants, analyzed the distribution characteristics of grit particles, and calculated the grit removal efficiency of the grit chambers, so as to investigate the characteristics of grit distribution in domestic municipal wastewater and provide reference for optimizing the design of grit removal process. The grit concentration in municipal wastewater ranged from 1.28 mg/L to 80.96 mg/L, and the grit with particle size greater than 212 μm (coarse grit) accounted for 22.25% to 74.14%. There were obvious differences in the distribution of grit concentration and particle size in the influent of each wastewater treatment plant. The measured target grit removal diameter of the aerated grit chambers and the vortex grit chambers in each plant was between 150 μm and 212 μm, and the weighted average grit removal rate ranged from 9.16% to 52.02%. The target grit removal diameter of these chambers could be improved to less than 150 μm, and the weighted average grit removal rate could be significantly increased by reducing the surface load of the vortex grit chambers to less than 60 m/h or extending the residence time of the aerated grit chambers to more than 10 min.
相似文献/References:
[1]张玲玲,曹洋,顾淼,等.高排放标准下城市污水深度脱氮技术研究[J].中国给水排水,2021,37(13):27.
ZHANG Ling-ling,CAO Yang,GU Miao,et al.Advanced Nitrogen Removal Technology of Municipal Wastewater under High Discharge Standard[J].China Water & Wastewater,2021,37(21):27.
[2]阮超,张延军,李胡爽,等.武汉大东湖城市污水深隧结构健康监测系统研究[J].中国给水排水,2021,37(20):126.
RUAN Chao,ZHANG Yan-jun,LI Hu-shuang,et al.Research on Structure Health Monitoring System of Dadonghu Urban Sewage Deep Tunnel in Wuhan[J].China Water & Wastewater,2021,37(21):126.
[3]张钰婷,尚巍,邱顺添,等.污水厂中有机磷的赋存形态、生物有效性及强化去除[J].中国给水排水,2023,39(4):12.
ZHANGYu-ting,SHANGWei,KHUSoon-thiam,et al.Occurrence, Bioavailability and Enhanced Removal of Organic Phosphorus in Municipal Wastewater Treatment Plant[J].China Water & Wastewater,2023,39(21):12.
[4]丁鑫,李祥,毕贞,等.厌氧/好氧交替生物膜工艺利用原水中碳源回收磷[J].中国给水排水,2023,39(5):1.
DINGXin,LIXiang,BIZhen,et al.Recovery of Phosphorus by Anaerobic/Aerobic Alternative Biofilm Process Using Organic Carbon from Raw Wastewater[J].China Water & Wastewater,2023,39(21):1.
[5]李啸川,闫昊,苑泉,等.城市污水双泥龄复合脱氮工艺的脱氮机理分析[J].中国给水排水,2023,39(9):10.
LIXiao-chuan,YANHao,YUANQuan,et al.Analysis on Denitrification Mechanism of Double-SRT Hybrid Denitrification Process for Municipal Wastewater Treatment[J].China Water & Wastewater,2023,39(21):10.
[6]刘敏,房阔,王凯军.AAO+流态化生物载体工艺的菌群结构分析[J].中国给水排水,2023,39(19):11.
LIUMin,FANGKuo,WANGKai-jun.Analysis on Microbial Community Composition of AAO+FBC/MBBR System[J].China Water & Wastewater,2023,39(21):11.