LIU Yan-hua,SU Xi-bo,GAO Ying-liang,et al.Renovation Technology and Practice of Horizontal Flow Sedimentation Tank in Urban Waterworks[J].China Water & Wastewater,2020,36(14):131-133.
城镇自来水厂平流沉淀池改造技术与实践
- Title:
- Renovation Technology and Practice of Horizontal Flow Sedimentation Tank in Urban Waterworks
- Keywords:
- waterworks; horizontal flow sedimentation tank; trussed sludge scraper; grille type water distribution wall; diversion wall; solid content of discharge sludge
- 摘要:
- 当前国内部分自来水厂的平流沉淀池由于建设时间较久，工艺设备使用寿命达限，普遍存在产水量低、出水浊度高、排泥含水率高、投药量大的问题，以及排泥设备老化带来的运行安全、运行效能下降问题，亟需进行优化改造，以提高净水效能。佛山市沙口水厂在原有平流沉淀池的基础上，对虹吸式排泥车、配水花墙、集水槽、导流墙进行了相应的技术改造及优化，通过本次改造，使得4#沉淀池排泥含固率稳定在3.0%以上；与尚未改造的3#池相比，在相同出水浊度的条件下，单池出水量提高30%，投药量下降3 mg/L，极大地提高了处理效率，降低了运行成本。
- Abstract:
- Since the horizontal flow sedimentation tanks in some domestic waterworks have been constructed for a long time, it is common that the equipment have reached service life, and the process has low water yield, high effluent turbidity, high water content of discharge sludge, large dosages, and decline of operation safety and operational efficiency caused by the aging of sludge discharge equipment. Based on the original horizontal flow sedimentation tank, Foshan Shakou Waterworks has carried out technical renovation and optimization on the siphon sludge scraper, inlet wall, decanting trough, and diversion wall. After that, the solid content of discharge sludge from the No.4 sedimentation tank was stable above 3.0%. Compared with the unmodified No.3 tank at the same effluent turbidity, the water yield was increased by 30%, the dosage was reduced by 3 mg/L, which greatly improved the treatment efficiency and reduced operating costs.
相似文献/References:
[1]黄仲均,刘佳伟.基于一体化净水装置的自来水厂改造扩能案例分析[J].中国给水排水,2018,34(22):82.
HUANG Zhong-jun,LIU Jia-wei.Reconstruction and Expansion Design of Waterworks Based on Integrated Water Purification Device[J].China Water & Wastewater,2018,34(14):82.
[2]李丰庆.我国超大超滤水厂——广州北部水厂工艺设计[J].中国给水排水,2021,37(10):66.
LI Feng-qing.Process Design of the Super Large Ultrafiltration Waterworks in China: Guangzhou Beibu Waterworks[J].China Water & Wastewater,2021,37(14):66.
[3]赵新娟,刘伯一.短流程超滤膜工艺在凌庄水厂的应用[J].中国给水排水,2021,37(10):71.
ZHAO Xin-juan,LIU Bo-yi.Application of Short Process Ultrafiltration Membrane in Lingzhuang Waterworks[J].China Water & Wastewater,2021,37(14):71.
[4]李建,王海梅,白筱莉,等.复合沉淀池的衍变及工程应用[J].中国给水排水,2021,37(12):31.
LI Jian,WANG Hai-mei,BAI Xiao-li,et al.Development and Engineering Application of Composite Sedimentation Tank[J].China Water & Wastewater,2021,37(14):31.
[5]黄孟斌,武洋,王梅芳,等.深圳长流陂水厂网格絮凝池提升改造应用实践[J].中国给水排水,2021,37(12):116.
HUANG Meng-bin,WU Yang,WANG Mei-fang,et al.Application Practice of Grid Flocculation Tank Upgrading and Reconstruction in Shenzhen Changliupi Waterworks[J].China Water & Wastewater,2021,37(14):116.
[6]何嘉莉,袁耀芬,周沛良,等.自来水厂混凝剂自动精准投加系统建设与运行[J].中国给水排水,2021,37(18):139.
HE Jia-li,YUAN Yao-fen,ZHOU Pei-liang,et al.Construction and Operation of Automatic and Accurate Coagulant Dosing System in Waterworks[J].China Water & Wastewater,2021,37(14):139.
[7]杨存满,鞠佳伟,袁芳,等.基于PSO-BP神经网络的水厂智能消毒预测模型[J].中国给水排水,2022,38(3):57.
YANGCun-man,JUJia-wei,YUAN Fang,et al.Research on Intelligent Disinfection Prediction Model of Waterworks Based on PSO-BP Neural Network[J].China Water & Wastewater,2022,38(14):57.
[8]陈仁杰,刘明辉,丁陈龙,等.基于水厂砂滤填料附着物的BAF启动及其硝化性能[J].中国给水排水,2022,38(8):25.
CHENRen-jie,LIUMing-hui,DINGChen-long,et al.Startup of Biological Aerated Filter Seeded with Attached Microbes from Sand Filter in a Waterworks and Its Nitrification Performance[J].China Water & Wastewater,2022,38(14):25.
[9]李颖强,麻庆广,刘则华,等.我国南方典型自来水厂中游离氨基酸浓度及去除特性[J].中国给水排水,2022,38(13):28.
LIYing-qiang,MAQing-guang,LIUZe-hua,et al.Concentration Level and Removal of Fifteen Free Amino Acids in Eight Drinking Water Treatment Plants in South China[J].China Water & Wastewater,2022,38(14):28.
[10]宋欣,李燕君,黄慧,等.臭氧-上向流BAC工艺对常规及新污染物的控制效果[J].中国给水排水,2024,40(3):1.
SONGXin,LIYan-jun,HUANGHui,et al.Control of Conventional and Emerging Contaminants by Ozone-Upflow Biological Activated Carbon Process[J].China Water & Wastewater,2024,40(14):1.